V60 (SPA)
Data covers 9 NHTSA model names
Reliability Score
Complaints by Engine Code
B4204T (MP)
2.0L 4-cyl Turbo / 250 hpView details
Complaint Breakdown
Show 2 additional engine variants with limited data
B4204TSH (HP)
2.0L 4-cyl Turbo / 328 hpView details
Complaint Breakdown
B4204T
2.0L 4-cyl / 247 hpView details
Complaint Breakdown
Battery & Propulsion Reliability
Plug-in Hybrid (PHEV)
Battery & propulsion complaint analysis for the 2019-2025 Volvo V60
Too few field reports to rate this generation against peers yet. Most recently launched models accumulate complaints over the first 2-3 years.
What kind of battery complaint?
Among the 1 battery-related complaints, here's the type mix. These percentages describe what the complaints are about — not how reliable the vehicle is overall.
Loss of power, drive unit, inverter, traction motor, DC-DC converter.
Battery & propulsion recalls (3)
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Consequence: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
Sample complaint excerpts
Electric Propulsion
- [2024] After two days of ownership and 148 miles, the car threw a check engine light w/ the following message: "SLOW DOWN. The vehicle will reduce speed. Propulsion system failure." followed by, "Propulsion system service required.". This consequently causes the car to go into 'limp mode' unexpectedly while driving, drastically reducing speed. We are then instructed to take it to a shop. [XXX] INFOR
Source: classified from NHTSA complaint and recall data. "Battery-related" includes high-voltage propulsion battery, charging system, hybrid drivetrain, electric propulsion, regenerative braking, 12V auxiliary battery, and thermal-event complaints. Other complaints (suspension, steering, brakes, infotainment) appear in the engine and vehicle-level sections. Rates are absolute counts, not normalized per-VIN — high-volume models naturally produce more raw complaints than low-volume ones. Self-reported death and injury counts are capped per complaint to limit form abuse.
Owner Complaints by System
Complaints owners filed with NHTSA about the Volvo V60, counted across every engine. A complaint can name more than one system.
Recalls (11)
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60, V60CC, V90CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Show 6 older recalls
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
NHTSA Safety Ratings About NHTSA ratings
All Generations
Frequently Asked Questions
What are the most common 2019-2025 Volvo V60 complaints?
Owners have filed 24 complaints with NHTSA about the 2019-2025 Volvo V60. The systems they name most often are the electrical system, the brakes and the safety systems.
Is the 2019-2025 Volvo V60 a good used car?
That depends on the model year, the mileage and the maintenance history of the car in front of you. Owners have filed 24 complaints with NHTSA about the 2019-2025 Volvo V60. Check which systems they name most often and whether a recall is still open on that car.
How many NHTSA complaints does the 2019-2025 Volvo V60 have?
NHTSA has 24 owner complaints on file for the 2019-2025 Volvo V60 as of the latest data pull. A complaint is an owner's report, not a confirmed defect, and counts rise with sales.
What recalls affect the 2019-2025 Volvo V60?
NHTSA lists 11 recalls covering some 2019-2025 Volvo V60 vehicles. Which ones apply depends on the VIN: enter it at nhtsa.gov/recalls to see the open campaigns on a specific car.
What should I check before buying a used Volvo V60?
Run the VIN through NHTSA's recall lookup and confirm every open recall has been done. Look hardest at the electrical system, the brakes and the safety systems, the systems owners complain about most. Ask for maintenance records, have an independent mechanic inspect the car and run a vehicle history report for prior accidents and title issues.
What are the NHTSA crash test ratings for the V60?
The 2025 Volvo V60 received an overall 5-star safety rating from NHTSA. Frontal crash: 4 stars. Side crash: 5 stars. Rollover: 5 stars (9.9% rollover probability). Electronic Stability Control: Standard. Forward Collision Warning: Standard. Lane Departure Warning: Standard. These ratings are based on standardized crash tests conducted by the National Highway Traffic Safety Administration.
Data from NHTSA federal complaints database. 24 complaints analyzed. Data confidence: low. Last updated: 2026-10-12.