Vnl (2007)
Engine Reliability Ratings
VE D12
12.1L 6-cyl / 425 hpView details
Complaint Breakdown
Known Issues
2 additional engine variants with fewer than 10 complaints not shown.
Recalls (9)
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
VOLVO TRUCKS IS RECALLING 366 MY 2006-2009 VNL TRUCKS EQUIPPED WITH SUPER SINGLE TIRES, BENDIX BRAKE CAM TUBES, AND VOLVO AIR SUSPENSION. THE VIBRATION FREQUENCY FROM THE SUSPENSION WITH SUPER SINGLE TIRES MAY RESULT IN A FATIGUE CRACK OF THE MOUNTING BRACKETS FOR THE BRAKE CAM TUBE.
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.
ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR WORK TO FRACTURE.
Frequently Asked Questions
What are the most common 2007-2007 Volvo Vnl problems?
The 2007-2007 Volvo Vnl has accumulated 15 NHTSA complaints. The most frequently reported problem areas are Exterior, Brakes, Body/Trim. As with any used vehicle, a pre-purchase inspection and vehicle history report are recommended.
Which Volvo Vnl engine is most reliable?
The 2007-2007 Volvo Vnl was offered with 3 engine options. Based on NHTSA complaint data, the 12.13L 6-cyl has the lowest complaint density and is considered the most reliable choice for buyers.
Is the 2007-2007 Volvo Vnl a good used car?
The 2007-2007 Volvo Vnl can be a solid used car purchase depending on trim, mileage, and maintenance history. With 15 total NHTSA complaints on record, prospective buyers should review the known problem areas and check for open recalls before buying.
How many NHTSA complaints does the 2007-2007 Volvo Vnl have?
The 2007-2007 Volvo Vnl has 15 complaints filed with NHTSA as of our latest data pull. Complaint counts reflect owner-reported issues and do not necessarily indicate defects or safety risks on their own.
What recalls affect the 2007-2007 Volvo Vnl?
There are 9 NHTSA recalls affecting some 2007-2007 Volvo Vnl vehicles. Recall status varies by VIN — check the NHTSA recall database at recalls.nhtsa.dot.gov with your specific VIN to confirm which campaigns apply.
What should I check before buying a used Volvo Vnl?
Before buying a used Volvo Vnl, verify all open recalls are completed via the NHTSA VIN lookup tool. Pay particular attention to Exterior, Brakes, Body/Trim, which are the most commonly reported problem areas. Request maintenance records, have an independent mechanic inspect the vehicle, and run a vehicle history report to check for prior accidents or title issues.
Does the Vnl have NHTSA crash test ratings?
NHTSA has not published crash test ratings for the 2007 Volvo Vnl. Not all vehicles are tested each year. For the latest NHTSA safety information, visit nhtsa.gov/ratings.
Data from NHTSA federal complaints database. 15 complaints analyzed. Data confidence: low. Last updated: 2026-04-07.